跨声速压气机转子叶尖泄漏涡非定常特性数值研究

为了研究跨声速单转子压气机系统叶尖泄漏涡的非定常特性,选取Rotor 67孤立转子为研究对象,针对不同背压工况与不同转速工况进行了非定常数值模拟。结果表明:在每一转速状态都存在一非定常边界,其将特性线分为定常部分和非定常部分。当转子运行在特性线非定常部分时,随着背压提高,叶尖泄漏涡脉动频率逐渐减小。这是由于背压提高使叶尖前缘负荷变小,叶尖泄漏涡的驱动力也变小。叶尖泄漏涡的频率特征与转子转速息息相关。高转速状态时叶尖泄漏涡主要表现出低频特征,低转速状态时叶尖泄漏涡主要表现出高频特征。这是由于转速不同,叶尖激波的脱体程度不同,激波对于叶尖泄漏涡的激励位置也不同。由非定常叶尖泄漏涡引起的压力波的周向传播速度在各转速下表现出较强的规律性。随着流量系数的减小,压力波波速呈线性减小趋势,且各转速下减小的速率大致相同。且在波速-流量系数曲线中,各转速的非定常状态起始点基本位于同一条直线。      

Large-eddy simulation and linear acoustic modeling of entropy mode oscillations in a model combustor with coolant injection

Lean-burn combustor is particularly susceptible to combustion instability and the unsteady heat release is usually considered as the excitation of the self-maintained thermo-acoustic oscillations. The transverse coolant injection is widely used to reduce the temperature of burnt gas, but on the other hand, it will introduce temperature fluctuation inside the combustor. Therefore, it is necessary to consider the influence of the coolant injection on combustion instability, and evaluate its dynamic feature. In this paper, Large-Eddy Simulation (LES) of the self-excited pressure oscillations in a model combustor with coolant injection is carried out. The analysis of transient flow characteristics and the identification of the pressure modes confirm that one of the low frequency pressure oscillations is related to entropy fluctuations, which is known as rumble combustion instability. The LES results show that transient coolant injection is another excitation of temperature fluctuation other than unsteady combustion. The amplitude of the entropy mode oscillation increases with increasing coolant air mass whereas the change of its frequency is insignificant. According to the major feature of entropy wave oscillation caused by coolant injection, a compact coolant injection model is proposed and applied in the One Dimensional (1D) Acoustic Network Method (ANM). Key correlations used in the model match well with LES data in low frequency range. This means that the coolant injection model is a complex one reflecting the interaction of the fluctuating coolant mass, pressure and temperature. Finally, the combustion instability frequencies and modes predicted by acoustic network method are also in good agreement with LES results.     

High-speed unsteady flows past two-body configurations

This paper presents a detailed investigation of unsteady supersonic flows around a typical two-body configuration, which consists of a capsule and a canopy. The cases with different trailing distances between the capsule and canopy are simulated. The objective of this study is to examine the detailed effects of trailing distance on the flow fields and analyze the flow physics of the different flow modes around the parachute-like two-body model. The computational results show unsteady pulsating flow fields in the small trailing distance cases and are in reasonable agreement with the experimental data. As the trailing distance increases, this unsteady flow mode takes different forms along with the wake/shock and shock/shock interactions, and then gradually fades away and transits to oscillate mode, which is very different from the former. As the trailing distance keeps increasing, only the capsule wake/canopy shock interaction is present in the flow field around the two-body model, which reveals that the unsteady capsule shock/canopy shock interaction is a key mechanism for the pulsation mode.     

热容法测量推进剂剩余量的地面试验

摘要： 热容法作为一种新的推进剂剩余量测量方法,由于具有实施方便、测量精度高等优点,适用于卫星在轨寿命末期的推进剂测量.为了验证热容法的可行性,考察热容法的测量精度,并对星上热容法方案给出实施建议,对某贮箱进行了热容法试验验证研究.在不同加热工况下,对不同试液装填量进行试验,采集不同测温点的热响应数据,通过对试验数据的分析,得出了热容法的测量精度,验证了热容法的可行性,并且提出了具体的实施建议,为热容法的后续在轨应用提供参考.     

卫星地面测控站的防雷技术

雷电是大气中带有大量电荷的雷云放电的结果,落地雷强大的雷电流可达数十至数百千安培。由于卫星测控站的天线通常是附近最高的建筑物,在雷雨季节容易招引雷电。文章在对卫星地面测控站的多起雷击事故进行调研统计的基础上,分析得出测控设备遭受雷击的原因,讨论了卫星地面测控站的防雷击理论和接地技术,提出测控站防雷击措施,主要包括等电位接地、等电位连接、机房电磁屏蔽、合理布线等。     

旋转爆震发动机燃烧室气膜出流影响数值研究

针对旋转爆震发动机（RDE）壁面的高热负荷问题,开展旋转爆震发动机燃烧室壁面气膜冷却的数值仿真,探究气膜出流与爆震波、斜激波和燃烧室流场之间的相互作用以及气膜对壁面的冷却特性。研究结果表明:爆震波对气膜的压缩和冷却孔的堵塞作用明显,气膜对爆震波整体的传播特性影响较小。受爆震波和燃烧室流场的影响,气膜出流存在周期性的摆动情况,这在一定程度上影响了壁面的冷却效果。在爆震波覆盖的壁面区域,峰值壁温下降程度有限,但时均壁温的降幅超过26.9%;在斜激波覆盖区域,随着冷气量的增加,峰值壁温和时均壁温的降幅超过32.5%和51.3%,气膜对该区域壁面的冷却效果更加明显。      

翼型波浪水面巡航地面效应数值模拟

数值求解非定常不可压缩流动的雷诺平均N-S(Navier-Stokes)方程和标准k-ε湍流模型,用VOR(Volume Of Fluid)方法模拟波浪水面,模拟了NACA2410翼型在波浪水面上方飞行的流场.研究了余弦波浪水面的生成方法,选取合适的计算网格和时间步长,避免了在生成规则余弦波浪水面时由于数值耗散使波面形状衰减.比较了固壁波浪与水面波浪计算结果的差异,发现固壁波浪的结果更接近余弦曲线分布.研究了波浪等级对翼型气动性能的影响,分析计算结果发现:在规则的余弦水面波浪上方飞行,翼型气动力呈现周期性,给出了一个周期内气动力的变化过程,以及波长和波幅对气动力平均值和波动幅度的影响规律.      

提高航天器超声检漏灵敏度的方法研究

应用超声进行航天器舱体及管道系统检漏是一种可快速定位漏点的无损检测方法,从试验方法及信号处理上可以有效提高各种工况下的检漏灵敏度。文章对非接触超声检漏提高有效湍流强度增强超声信号和接触超声检漏改变信号带通频率这两种方法进行了试验研究。结果显示,采用这两种方法均能增强有效信号强度,提高检漏灵敏度。     

Influence of shock attenuation on tailored operation in free piston shock tunnels

The free piston shock tunnel is a type of shock tunnel with high performance. For this type of tunnel, the influence mechanism of shock wave attenuation on tailored operation is explored by numerical simulation and theoretical analysis. By introducing the normalized velocity, the simple constraint equation for shock wave under the tailored operation is deduced. Moreover, the real gas effect is also taken into account in this equation. Based on the equation, the tailored operation of shock tunnels can be predicted with very few calculations. The present study shows that the change rate of the thermodynamic state of the gas behind the shock wave is inconsistent with the attenuation rate of the shock wave, which is the fundamental reason why the wind tunnel achieves tailored operation at a lower Mach number of shock waves. This lower Mach number of shock waves differs from the corresponding ideal value by a factor, which is about the square root of shock attenuation rate.