关系矩阵法在发动机执行机构故障检测中的应用

作为航空发动机控制系统的重要组成部分, 执行机构的故障检测与隔离目前尚缺少有效方法.本文提出了一种新颖的解决问题途径, 利用相互关系矩阵, 通过发动机输出与控制器指令计算执行机构输出的偏差, 可以达到检测、隔离多个执行机构故障的目的.数字仿真表明, 这一方法在航空发动机执行机构故障检测中, 具有较高的准确性.      

利用二次优化实现柔性冗余度机器人关节力矩最小化研究

对基于振动抑制的柔性冗余度机器人关节力矩的最小化进行了研究。通过分析影响柔性机器人弹性动力响应的因素,得出了在结构参数不变的情况下可以通过适当调整关节运动参数来提高机器人动态性能的结论。在此基础上,通过对柔性冗余度机器人的关节运动进行研究,提出了通过自运动的适当选取从而抑制机器人柔性振动的方法。通过对满足抑振要求的自运动的选取进行分析,指出柔性冗余度机器人在实现振动抑制的基础上还具有二次优化的能力,并且利用这种二次优化的能力得出了基于振动抑制的最小化关节力矩的方法。数值仿真验证了该方法的有效性。     

电致动聚合物致动器材料及放大结构综述

为满足航天应用的需要,本文对EAP材料研究情况和它们典型的压电致动器放大结构发展趋势进行了综述。首先比较了干湿EAP材料的特性,提出了应用中需要注意的一些问题;其次,以典型的压电致动器放大结构为例,分析了其优缺点,强调了一些新颖的概念。最后指出,为克服航天应用中EAP致动器力和行程的限制,需要根据实际应用从材料和放大结构两方面展开深入研究。     

一种新型微型杆式超声电机及其驱动原理

提出了一种新型微型杆式超声电机,并对该杆式电机的驱动机理进行了仿真。该电机采用两段金属柱体压紧5片压电陶瓷片作为定子。该定子结构和压电陶瓷片的布局方式可以提高其机电转换效率。为尽量减小定、转子之间的径向滑移以提高摩擦传动效率,电机采用了柔性转子,对原理样机及其微型驱动器进行了性能实验。电机的外径为9mm,长度为15mm,重3.2g。当电机工作在杆式定子的一阶弯曲频率(72kHz)附近时,电机实测最大转速为520r/min,最大输出力矩为4.5mN·m。实验结果表明,该电机具有良好的稳定性,利用频率自动跟踪技术对电机转速进行闭环控制,可以将其转速波动稳定在3%之内。     

星载综合孔径微波辐射计冗余空间定标方法研究

星载综合孔径微波辐射计系统为了实现更好的辐射测量性能,在地面对通道间剩余相位通过相位定标实验进行测量,其结果用于亮温重构时对通道间剩余相位进行补偿。冗余空间定标方法基于自身阵列冗余基线信息,该方法无需额外资源支持即可对星载综合孔径微波辐射计系统定标,可作为一种在轨的验证方案对系统综合孔径微波辐射计系统通道间剩余相位进行评估。系统性的介绍了基于星载综合孔径微波辐射计系统观测到的场景,冗余空间定标方法以及对平坦场景提出利用模拟的平坦目标响应相位修正的方法,可在点源场景、平坦场景下利用冗余空间定标方法求解通道间剩余相位,并结合仿真验证该方法的可行性。     

一种航天测控冗余跟踪弧段处理方法

随着在轨航天器的日益增多,测控资源的需求量也日益增大,因此,其使用效率也倍受关注。当航天器重要测控弧段安排多个测控设备进行全力跟踪时,很容易出现测控弧段搭接或完全被覆盖的情况。为有效利用现有测控资源,针对弧段搭接的情况,提出了一种基于冗余度评价函数的跟踪弧段处理方法,该方法在不降低跟踪总时长情况下,通过合理有效地配置测控资源,剔除了冗余跟踪弧段,提高了现有测控资源的使用效率。     

Experimental study of an insert and its influence on churning losses in a high-speed electro-hydrostatic actuator pump of an aircraft

The speed of an Electro-Hydrostatic Actuator (EHA) pump can recently reach 20000 r/min, and its churning losses increase obviously with an increasing speed, which results in low efficiency and thus increasing heat in aircraft EHA systems. In order to reduce churning losses at high speeds, more attention should be given to the design of an insert. In this paper, the effect of an insert with different design parameters on churning losses is investigated through Computational Fluid Dynamics (CFD) simulation and experiments by calculating the difference between churning losses torques of the test pump with and without the insert based on a high-speed churning losses test rig. Analytical results show that the gap between the insert and the cylinder is critical for churning losses reduction. It is found that the churning losses of the test pump can be reduced with a decreasing gap between the cylinder block and the insert at high speeds. This is because the insert can decrease the turbulence occurrence at high speeds. The results can be used for flow field analysis and optimization of the high-speed EHA pump and provide a new method for improving efficiency of high-speed EHA pumps.     

关于约束分类问题的研究

约束条件的分类对于简化数学规划问题的求解具有重要意义，对于凸函数ｇｉ（ｘ）（ｉ＝１，２，…，ｎ）给出了约束ｇｉ（ｘ）≤０是必要约束或多余约束的充要条件，对于一般约束，定义了约束相关矩阵，给出了约束是必要的或多余的充要条件，对相对多余约束给出了分类。     

某型飞机空中飘摆故障分析及防护措施

分析某型飞机平尾助力器故障导致飞机在空中飞行时产生飘摆现象的原因,提出修理改进措施及维护对策。     

Active fault tolerant control for vertical tail damaged aircraft with dissimilar redundant actuation system

This paper proposes an active fault-tolerant control strategy for an aircraft with dissim-ilar redundant actuation system (DRAS) that has suffered from vertical tail damage. A damage degree coefficient based on the effective vertical tail area is introduced to parameterize the damaged flight dynamic model. The nonlinear relationship between the damage degree coefficient and the corresponding stability derivatives is considered. Furthermore, the performance degradation of new input channel with electro-hydrostatic actuator (EHA) is also taken into account in the dam-aged flight dynamic model. Based on the accurate damaged flight dynamic model, a composite method of linear quadratic regulator (LQR) integrating model reference adaptive control (MRAC) is proposed to reconfigure the fault-tolerant control law. The numerical simulation results validate the effectiveness of the proposed fault-tolerant control strategy with accurate flight dynamic model. The results also indicate that aircraft with DRAS has better fault-tolerant control ability than the traditional ones when the vertical tail suffers from serious damage.