A sounding rocket experiment on the marangoni convection

During a 6-minutes free flight of a sounding rocket an experiment on the thermal Marangoni convection in a right circular cylindric floating zone was carried out to verify the thermal Marangoni convection by flow visualisation for the first time at 10^?4 g. From the motion picture analysis the velocity distributions are obtained. The interdependence between the two velocity maxima and the S-shaped temperature distribution on the free surface is discussed. The influence of the heat transfer caused by the flow of the surrounding air induced by the thermal Marangoni convection itself is considered briefly.     

环形浅液池内低Prandtl数流体超临界热毛细对流演化

为研究低Prandtl数（Pr）流体热毛细对流演化过程，对环形浅液池内Pr=0.011的流体热毛细对流进行三维数值模拟.研究发现:当Marangoni数较小时，流动为轴对称稳态流动；当Marangoni数超过某一临界值后，流动失稳并转变为热流体波，其波数随Marangoni数增加而减小，而波动主频增大；随着Marangoni数增加，流动加强，沿周向运动的热流体波演变为沿径向运动的径向波，其波数大大减小；当Marangoni数继续增加时，波动频谱曲线噪声增加，呈广谱特性.因此，在计算范围内热毛细对流的演化过程为:轴对称稳态流动-热流体波-单周期径向波-多周期三维振荡流动.      

微重力环境下蒸发液层热毛细对流的数值模拟

提出了一种新模型来研究由单一物质构成的液层在其纯蒸气中的蒸发.液层置于微重力环境中并且受到水平方向温度梯度的作用,液层的热毛细对流和蒸发耦合在一起,使得气液界面的传热传质规律更加复杂.用理论分析的方法求解了不考虑热毛细效应的纯蒸发模型,得出温度场分布和界面质量流量的解析表达式.对于热毛细对流和蒸发耦合情况,采用有限差分的投影算法同时求解Navier-Stokes方程和能量方程,得到了不同蒸发Biot数和Marangoni数下流场和温度场的稳态数值解.论述了蒸发Biot数和Marangoni数对界面传热传质的影响,提出并解释了蒸发和热毛细对流耦合的三种模式.      

Onset of Marangoni convection in an infinite layer of an electrically conducting liquid under magnetic field

The onset of Marangoni convection in an electrically conducting liquid is studied theoretically for the case that the liquid is subjected to a vertical temperature gradient and a magnetic field with arbitrary orientation.The effects of the intensity of magnetic field, the angle of inclination of magnetic field and the Biot number at the free surface on both the critical Marangoni number and the flow pattern are made clear.     

Two-dimensional convection in liquid layer related to crystal growth techniques in space

In this paper, the Marangoni convection including buoyancy convection in two-dimensional fluid model was investigated experimentally and theoretically. The transparent liquid in the test cell was heated and cooled under various conditions. The fluid flow driven by surface tension and by buoyancy force was visualized and measured. The flow patterns, velocity distributions and temperature field were obtained and they were compared with the results of the numerical solutions. The effect of the configuration and the convection in microgravity on crystal growth was discussed. The temperature field of the crystallizing surface was predicted.     

过冷核态池沸腾中的Marangoni效应

分析了过冷核态池沸腾过程中气泡横向运动现象,指出其成因在于相邻气泡界面温度差引起的Mara-ngoni对流对周围液体的吸引.通过对该流动的尺度分析,得到了气泡横向运动特征速度及其可观测度的估算公式,其预测结果与实验观测相一致.特别是对极细小的初始核化气泡,该公式预测了强烈的横向Marangoni对流会导致气泡顶端微射流的形成.该效应在加热面水平向下或微重力沸腾等气泡脱落频率较低的情形中尤为重要.      

Improvement of flight hardware and isothermal Marangoni convection under micro-gravity conditions

During parabolic flights three different kinds of experiments were performed under reduced gravity conditions. The experiments were: I. A general learning process to work with hardware and fluid under micro-gravity conditions. II. The investigation of critical parts of hardware or critical moments in experiments. This can be a part in the preparation of future sounding rocket or Spacelab flights. III. The possibility to perform scientific experiments under micro-gravity conditions within 22 seconds. In the joined parabolic flights of march 1986 the main interest was to perform experiments with Marangoni convection due to concentration gradients along the gas-liquid interface under isothermal conditions. One experiment was performed with a horizontal surface tension gradient and the other observed Marangoni convection was due to the evaporation of a component from a solution under steady state conditions.     

天舟一号货运飞船空间实验装置蒸发相变地面实验

以天舟一号货运飞船为依托,开展空间蒸发相变传热规律的科学实验研究,探索重力对蒸发传热传质过程的影响规律.设计了一套地面蒸发实验平台,以蒸发相变液体FC-72为研究对象,通过红外热像仪测温、热流量计、差分热电偶等手段,观测FC-72液层在不同台面温度、注液量等情况下的相变界面变化、蒸发表面特性、流体物性及Marangoni对流涡胞的变化等,获取其蒸发两相流体的液层温度差、表面温度场、热流量值、蒸发速率和涡胞结构等.实验结果表明:在其他条件不变的情况下,FC-72液层与蒸发台面的温差越高,其蒸发速率越快;注液量越大,蒸发速率也越大;在蒸发过程中出现了浮力对流涡胞和Marangoni对流涡胞.此外,通过地面蒸发实验可以确定空间科学实验选用的实验介质和材料,进而优化确定空间科学实验的工况、参数及流程等,部分地面实验结果也将直接成为天地对比实验的科学成果.      

Marangoni convection and mass transfer from the liquid to the gasphase

Marangoni convection can be introduced by instabilities in the evaporation of a component of a solution, under isotermal conditions. Three experiments were performed under micro-gravity conditions, to prevent density induced Rayleigh convections, during the D1-Spacelab flight. With a flat gas-liquid interface the system was stable, while a two-dimensional linear stability analysis predicts the system to be unstable. Deformation of the interface introduced concentration and thus surface tension gradients. The resulting Marangoni convection will enhance the mass transfer of the evaporation process.     

Oscillatory thermocapillary convection in floating zones under normal- and micro-gravity

The thermocapillary convection in a floating zone becomes oscillatory, exceeding a Marangoni number of approximately 10⁴. The oscillatory state of thermocapillary convection has been verified under 1 g and 10^?4 g and the features seem to be fairly independent of the gravity level. The transition point from the laminar to the oscillatory state (critical Marangoni number), however, depends on the magnitude and direction of the buoyant force.     

Hydrothermal instability of thermocapillary convection in large-Prandtl-number liquid bridges under microgravity

Linear stability analysis was performed to study the mechanism of transition of thermocapillary convection in liquid bridges with liquid volume ratios ranging from 0.4 to 1.2, aspect ratio of 0.75 and Prandtl number of 100. 2-D governing equations were solved to obtain the steady axi-symmetric basic flow and temperature distributions. 3-D perturbation equations were discretized at the collocation grid points using the Chebyshev-collocation method. Eigenvalues and eigenfunctions were obtained by using the Q–R method.The predicted critical Marangoni numbers and critical frequencies were compared with data from space experiments. The disturbance of the temperature distribution on the free surface causes the onset of oscillatory convection. It is shown that the origin of instability is related to the hydrothermal origin for convections in large-Prandtl-number liquid bridges.     

Correlation of oscillations of flow and temperature in floating zone under microgravity

The correlation between oscillations of flow and temperature of the Marangoni convection in a cylindric floating zone are studied. Photographs of the oscillating flow patterns are taken by triggering with a thermocouple signal of the temperature oscillation to reveal the frequency and phase correlations. Whilst both frequencies coincide, phase shift between temperature and flow oscillations exists.     

Two-dimensional Marangoni and buoyancy convection related to crystal growth techniques in space

The natural convection in the horizontal liquid layer driven both by surface tension gradient and buoyancy was investigated experimentally and theoretically.The fluid motion was visualized by mixing fine flakes of aluminum into the liquid. At the same time, the temperature field was visualized by the Mach-Zehnder interferometry and the local temperature gradient distributions were visualized by making use of the refraction of parallel incident light.The numerical analysis using the Galerkin method was also carried out which agreed well with the experimental results.It was found that the velocity and temperature fields of Marangoni convection were varied depending on the aspect ratio of the liquid layer and on the coupled buoyancy convection.     

Marangoni and buoyant convection in an open cavity under reduced and under normal gravity

We give the first full analysis of the microgravity experiment MKB ( arangoni onvektion im offenen oot) conducted on board of the space shuttle during the D1-mission in 1985, together with that of some ground based experiments on thermocapillary flow in a rectangular liquid volume with free upper surface. Streamlines and velocity profiles under μ-g and l-g are presented and discussed. Strong thermocapillary flow was observed under μ-g after the rupture of a dirt-film suppressing surface tension forces. The Nusselt-number under microgravity due to thermocapillary flow for Ma = 4.6 · 10⁵ is at least Nu = 6 ± 1. Under l-g a separation of the surface tension driven convection roll of hot fluid circulating on top of colder fluid was found for large Ma. The coupling and decoupling of buoyant and thermocapillary forces has been further studied in an experiment varying the temperature gradient along the free surface independently from that in the bulk fluid.     

Marangoni convection in a liquid layer under the simultaneous action of a transverse magnetic field and rotation

Asymptotic stability characteristics with respect to the onset of Marangoni convection in a liquid layer under the simultaneous action of a large transverse magnetic field and a large rate of rotation are investigated. In certain parameter ranges there is a decrease in critical Marangoni number for increasing magnetic field and rotation depending on the coupling between interfacial perturbations and rotation.     

空间微重力条件下偏晶合金的研究

利用我国首次卫星搭载,进行了偏晶合金Zn—Pb、Al—Pb 的空间微重力下的重熔试验,研究了低于临界温度下Al—Pb 合金重熔过程中的物理规律;在临界温度之上重熔了Zn—Pb 合金,发现了Marangoni 对流对合金凝固过程的影响;在液态烧结条件下制备了均匀的粉末Zn—Pb 合金。在微重力下的研究表明:空间微重力条件对消除由于重力引起的宏观偏折和自然对流十分重要,但在重力消失后,非重力的其它因素的影响又显得格外重要。     

Attempt to study Marangoni flow of low-Pr-number fluids using a liquid bridge of silver

In order to experimentally investigate the Marangoni flow of low-Prandtl-number fluids in a liquid bridge geometry under the condition of small Marangoni numbers close to the critical Marangoni numbers Ma_c1 and Ma_c2, the formation of a liquid bridge of silver was attempted. The available temperature difference between the upper and lower rods to obtain a small Marangoni number, such as Ma = 50, was calculated for a 5 mm high liquid bridge for several molten metals. For molten silver, the possible temperature difference was estimated to be 16 K, whereas, for molten silicon, this was 0.38 K, which is unrealistic for the purposes of experiments. For silver, a free surface can be obtained in the wide range of oxygen partial pressures, whereas, for molten silicon, the available oxygen partial pressure range is very small; equilibrium oxygen partial pressure for SiO₂ formation is as low as 1.1 × 10⁻¹⁴ Pa. A liquid bridge of molten silver was successfully prepared and temperature oscillation was observed; the estimated Marangoni number was 160 and oscillation frequency was 0.26 Hz.     

纵向非均匀多孔介质Marangoni对流不稳定性

理论研究了纵向非均匀多孔介质中流体表面张力驱动的对流不稳定性.充满液体的多孔介质层从下方加热,上方自由表面冷却,形成可引起多孔介质液层Marangoni-Benaxd对流流动的纵向温度梯度.采用线性化的Brinkman-Forchheimier方程作为控制方程组,对孔隙率分别为线性函数、正弦三角函数分布的非均匀多孔介质液层的Marangoni-Benaxd问题进行了线性稳定性分析.通过采用Chebyshev-Tau谱方法求解广义特征值问题,得到了系统临界Maxangoni数随无量纲波数变化的中性稳定性曲线,分析和比较了孔隙率的变化对液层对流稳定性和流场结构的影响,获得了纵向非均匀多孔介质液层不稳定性现象的新特征.      

EURECA and SGF performances

The EURECA platform offers unique characteristics for microgravity research: a very low level micro-gravity spectrum and a long operation time for recoverable experiments.

Five core facilities on board will perform an impressive number of experiments. The main purpose of the Solution Growth Facility (SGF) is growing crystals at low temperatures by using the double diffusion technique in three compartment reactors. The micro-gravity eliminates the convection in the liquid, while Marangoni convection is avoided by the absence of free surfaces. The thermal gradient in the buffer zone is better than 0.01°C/cm. Turbulence is eliminated by control of the valve rate and by a pressure compensation system. All surfaces are coated with Halar. The diffusion rate can be controlled by the use of filters. The SGF contains three independently controlled reactors.

A forth reactor contains an experiment aiming at measuring the Soret coefficient of twenty binary organic mixtures and aqueous electrolyte solutions.     

微重力池沸腾中的气泡和传热行为数值模拟

基于标准动量传输方程、连续性方程以及能量方程,建立了单个气泡的二维数值模型,考察了微重力过冷核态池内沸腾中的气泡动力学和传热行为.在动量传输方程中耦合了表面张力和Marangoni力,连续性方程和能量方程中耦合了相变效应,考虑了加热面上过热液体层的影响,并引入相场函数捕捉气液界面的动态变化.结果表明:气泡在生长过程中,形状由最初的半球形变为椭球形,最后变为脱附时的梨形;气泡在加热面上自由迁移,呈非轴对称结构,并且气泡上部的温度场呈现为蘑菇云状;气泡的脱附直径正比于g-0.488,脱附周期正比于g-1.113,加热面上的平均热通量正比于g0.229.