Food production and gas exchange system using blue-green alga (Spirulina) for CELSS.

In order to reduce the cultivation area required for the growth of higher plants in space adoption of algae, which have a higher photosynthetic ability, seems very suitable for obtaining oxygen and food as a useful source of high quality protein. The preliminary cultivation experiment for determining optimum cultivation conditions and for obtaining the critical design parameters of the cultivator itself has been conducted. Spirulina was cultivated in the 6-liter medium containing sodium hydrogen carbonate solution and a cultivation temperature controlled using a thermostat. Generated oxygen gas was separated using a polypropyrene porous hollow fiber membrane module. Through this experiment, oxygen gas (at a concentration of more than 46%) at a rate of 100-150 ml per minute could be obtained.     

Design for a bioreactor with sunlight supply and operations systems for use in the space environment.

An experiment was carried out to determine the characteristics of an operations system that can support fast cultivation of algae at high densities in the weightlessness of space. The experiment was conducted in glass bioreactor tanks, in which light was supplied by radiator rods connected to optical fiber cables. The illumination areas of the tanks were 2600 cm2, 6000 cm2, and 9200 cm2 per liter of solution. The characteristics of O2-CO2 gas exchange, concentration and separation of chlorella in the growth medium, dialysis of ionic salts in the growth medium, etc. were examined. Chloralla ellipsoidea was used in the experiment, yielding the following results: (1) By increasing the ratio of illumination area to volume, growth rates of up to approximately 0.6 g/L h could be obtained in a highly concentrated solution (one that contains 20 g/L or more of algae). (2) The most suitable proportions of carbon dioxide and oxygen gases for growing algae quickly at high concentrations were found to be 10% CO2 and 10% O2 (by volume). (3) There was a high optimum concentration for fast cultivation, and the data obtained resembled the theoretical curve postulated by P. Behrens et al. (4) It was possible to exchange carbon dioxide and oxygen using gas-permeable membrane modules. (5) It was possible to separate the chlorella from the growth medium and recycle the medium.     

Operation of an experimental algal gas exchanger for use in a CELSS.

Concepts of a CELSS anticipate the use of photosynthetic organisms (higher plants and algae) for air revitalization. The rates of production and uptake of carbon dioxide and oxygen between the crew and the photosynthetic organisms are mismatched. An algal [correction of aglal] system used for gas exchange only will have the difficulty of an accumulation or depletion of these gases beyond physiologically tolerable limits (in a materially closed system the mismatch between assimilatory quotient (AQ) and respiratory quotient (RQ) will be balanced by the operation of the waste processor). We report the results of a study designed to test the feasibility of using environmental manipulations to maintain physiologically appropriate atmospheres for algae (Chlorella pyrenoidosa) and mice (Mus musculus strain DW/J) in a gas-closed system. Specifically, we consider the atmosphere behavior of this system with Chlorella grown on nitrate or urea and at different light intensities and optical densities. Manipulation of both the photosynthetic rate and AQ of the alga has been found to reduce the mismatch of gas requirements and allow operation of the system in a gas-stable manner. Operation of such a system in a CELSS may be useful for reduction of buffer sizes, as a backup system for higher plant air revitalization and to supply extra oxygen to the waste processor or during crew changes. In addition, mass balance for components of the system (mouse, algae and a waste processor) are presented.     

Interaction of a mixed yeast culture in an "autotroph-heterotroph" system with a closed atmosphere cycle and spatially separated components.

The study considers an experimental model of the "autotroph-heterotroph" system with a closed atmosphere cycle, in which the heterotrophic link is a mixed yeast population. The autotrophic link is represented by the algae Chlorella vulgaris and the heterotrophic link by the yeasts Candida utilis and Candida guilliermondii. The controls are populations of Chlorella and the same yeasts isolated from the atmosphere. It has been shown that the outcome of competition in the heterotrophic link depends on the strategy of the yeast population towards the substrate and oxygen. The C. utilis population quickly utilizes the substrate as it is an r-strategist and is less sensitive to oxygen deficiency. The C. guilliermondii population consumes low concentrations of the substrate because it is a K-strategist, but it is more sensitive to oxygen deficiency. That is why, in the "autotroph-heterotroph" system with a closed gas cycle, after a considerable amount of the substrate has been consumed, the C. guilliermondii population becomes more competitive that the C. utilis population. In the culture of yeasts, isolated from the atmosphere, the C. utilis population finds itself in more favorable conditions due to oxygen deficiency. The system with a complex heterotrophic component survive longer than a system whose heterotrophic component is represented by only one yeast species. This is explained for by the positive metabolite interaction of yeasts and a more complete utilization of the substrate by a mixed culture of yeasts featuring different strategies towards the substrate.     

地外人工光合成装置研制与试验

原位资源利用技术是地外生命保障体系构建、实现人类地外生存的有效途径，是载人深空探索的核心技术。基于微通道技术的人工光合成反应器，采用流动反应器设计，用于低微重力等特殊环境条件下模拟人工光合作用，实现CO２向O２和含碳燃料的转化。微通道芯片通过气液剪切作用力使气体反应产物快速脱离电极表面并随反应介质排出反应器，理论上可以克服微重力条件对反应过程的影响，尚需进行微重力试验进行验证。同时，微通道结构可以通过精确控制反应气液的压力、流速、流量比等反应条件，获得优化的反应条件。通过地面试验，验证了该反应器将CO２还原为O２和含碳化合物的功能可行性。以Au和Ir/C作为阴极和阳极材料，3V电压条件下，O２产率可达11.74mL/h。此外，基于人工光合成反应器搭建了集反应模块、控制模块、流路驱动模块以及检测模块等于一体的地外人工光合成装置，形成原位反应、介质供给、精确控制、在线收集和检测等功能一体化的系统，并实现CO２有效转换和O２供给。为后续技术成熟度更高的反应装置研制、高产物选择性的含碳化合物转化以及人工光合成反应装置在轨试验奠定了理论和实践基础。     

Measurement of rice crop metabolism using closed-type plant cultivation equipment.

In order to determine a required plant cultivation area which can sustain human life in a closed environment, the material circulating measurement system including a Closed-type Plant Cultivation Equipment (CPCE) in which the metabolic data of plants can be accurately measured has been constructed. According to results from cultivation experiments using rice, the harvest index was 29.9% for 110 days, and the required crop area to supply food, oxygen and water for one person was calculated to be about 111m2, 36m2 and 0.9m2, respectively.     

Atmosphere behavior in gas-closed mouse-algal systems: An experimental and modelling study

Concepts of biologically-based regenerative life support systems anticipate the use of photosynthetic organisms for air revitalization. However, mismatches in the rates of production and uptake of oxygen or carbon dioxide between the crew and the plants will lead to an accumulation or depletion of these gases beyond tolerable limits. One method for correcting these atmospheric changes is to use physicochemical devices. This would conflict with the constraint of minimal size and weight imposed upon the successful development of a competitive bioregenerative system. An alternate control strategy is based upon reducing the gas exchange mismatch by manipulation of those environmental parameters known to affect plant or algae gas exchange ratios. We have initiated a research program using a dual approach of mathematical modelling and laboratory experimentation aimed at examining the gas exchange characteristics of artificial animal/plant systems closed to the ambient atmosphere. Our goal is to develop control techniques and management strategies for maintaining the atmospheric levels of carbon dioxide and oxygen at physiological levels. A mathematical model simulating the atmospheric behavior in these systems has been developed and an experimental gas-closed system has been constructed. These will be described and preliminary results will be presented.     

Basic design concept of Closed Ecology Experiment Facilities.

In order to study the relationship between the physiological metabolism of living things and the environmental factors such as the atmospheric contents and so on within the closed ecosystem, Closed Ecology Experiment Facilities (CEEF) were designed and now under construction based on the following concepts: (1) Individual sealed chambers (called modules) for the plant cultivation, animal breeding, human habitation and microbial waste treatment are to be constructed independently to be able to study the metabolic effects of each living thing on the environmental factors within closed ecosystem. (2) A chamber for the microbial waste treatment are to be replaced with two systems; wet oxidation reactors and chemical nitrogen fixation reactors. (3) Atmospheric control systems are to be independently attached to each module for stabilizing atmospheric contents in each module. (4) Any construction materials having the possibility to absorb oxygen and carbon dioxide are to be prohibited to use in each module for sustaining material balance. (5) Facilities have to be developed so that the closed plant and animal experiments can be done independently, as well as integrated experiments with plants and animals through exchanging foods, carbon dioxide, oxygen, condensed water and nutrient solution.     

Design and operation of an algal photobioreactor system.

A photobioreactor system has been designed, constructed, and implemented to achieve efficient oxygen production for a closed ecological life support system (CELSS). The special features of this system are the optical transmission system, uniform light distribution, continuous cycling of cells, gravity-independent gas exchange, and an ultrafiltration unit. The fiber optic based optical transmission system illuminates the reactor internally and includes a light source which is external to the reactor, preventing heat generation problems. Uniform light distribution is achieved throughout the reactor without interfering with the turbulent regime inside. The ultrafiltration unit exchanges spent with fresh media and its use results in very high cell densities, up to 10(9) cells/ml for Chlorella vulgaris. The prototype photobioreactor system was operated in a batch and continuous mode for over two months. The oxygen production rate measured at 4-6 mmoles per liter of the culture per hour under continuous operation, is consistent with the expected performance of the unit for the provided light intensity.     

Competition between links in "producer-consumer" trophic chains in an aquatic closed system with spatially separated components.

The work analyzes functioning of a "producer-consumer" closed aquatic system with spatially separated links, where each component consisted of two species. Producers in the system were the microalgae of Chlorella vulgaris and Scenedesmus sp., consumers--Paramecium caudatum infusoria and Brachionus sp. rotifers. In the experiment the competing predators were consuming on a mixed culture of algae, and the competition of algae was studied under nitrogen limitation. Under these conditions competitiveness of Scenedesmus was higher than that of Chlorella vulgaris. Metabolism products of Scenedesmus algae have been found to have negative effect on reproduction of Paramecium caudatum protozoa. Predator population dynamics in the "consumer" link demonstrated that the rotifers that consume two algal species are more competitive compared to protozoa feeding on chlorella only. Grant numbers: N99-04-96017, N25.     

飞行包线下燃油箱耗氧型催化惰化系统性能研究

为给新型耗氧催化惰化系统部件设计提供输入参数，在提出低温可控耗氧催化惰化系统流程基础上，以燃油箱出口抽吸流量为基准，基于质量守恒和能量守恒方程，建立了系统流程模型。以中央燃油箱为对象，仿真研究了全飞行包线下惰化系统的重要性能变化，以及关键参数对其影响。结果表明:惰化系统可以有效降低氧体积分数，如在初始满载、催化效率0.5、风机抽吸流量60 L/min条件下，24 min后氧体积分数即降至12%以下；在飞行过程中，燃油箱气相氧氧体积分数在下降及进场阶段上升，其他阶段均呈下降趋势；催化效率越高、风机抽吸流量越大，所需惰化时间越小，且催化效率一定时，达到相同惰化时间，初始空载时所需风机抽吸流量最大。应按最不利的空载工况来设计耗氧型催化惰化系统。      

Development of a ground-based space micro-algae photo-bioreactor

The purpose of the research is to develop a photo-bioreactor which may produce algae protein and oxygen for future astronauts in comparatively long-term exploration, and remove carbon dioxide in a controlled ecological life support system. Based on technical parameters and performance requirements, the project planning, design drafting, and manufacture were conducted. Finally, a demonstration test for producing algae was done. Its productivity for micro-algae and performance of the photo-bioreactor were evaluated. The facility has nine subsystems, including the reactor, the illuminating unit, the carbon dioxide (CO₂) production unit and oxygen (O₂) generation unit, etc. The demonstration results showed that the facility worked well, and the parameters, such as energy consumption, volume, and productivity for algae, met with the design requirement. The density of algae in the photo-bioreactor increased from 0.174 g (dry weight) L⁻¹ to 4.064 g (dry weight) L⁻¹ after 7 days growth. The principle of providing CO₂ in the photo-bioreactor for algae and removing O₂ from the culture medium was suitable for the demand of space conditions. The facility has reasonable technical indices, and smooth and dependable performances.     

Simulation of the MELiSSA closed loop system as a tool to define its integration strategy

Inspired by a terrestrial ecosystem, Micro-Ecological Life Support System Alternative (MELiSSA) is a project focused on a closed-loop life support system intended for future long-term manned missions (Moon and Mars bases). Started by the ESA in 1989, this 5-compartment concept has evolved through a mechanistic engineering approach designed to acquire both theoretical and technical knowledge. In its current state of development, the project can now start to demonstrate the MELiSSA loop concept at pilot scale. Thus, an integration strategy for a MELiSSA Pilot Plant (MPP) has been defined, describing the different test phases and connections between compartments. The integration steps are due to be started in 2008 and completed with a complete operational loop in 2015. The ultimate objective is to achieve a closed liquid and gas loop fulfiling 100% of oxygen requirements and at least 20% of food requirements for one-man. Although the integration logic could start with the most advanced processes in terms of knowledge and hardware development, this logic needs to be expanded to encompass a high-level simulation policy. This simulation exercise will make it possible to run effective demonstrations of each independent process, followed by progressive coupling with other processes in operational conditions mirroring as far as possible the final configuration.     

Mammalian cell cultivation in space.

Equipment used in space for the cultivation of mammalian cells does not meet the usual standard of earth bound bioreactors. Thus, the development of a space worthy bioreactor is mandatory for two reasons: First, to investigate the effect on single cells of the space environment in general and microgravity conditions in particular, and second, to provide researchers on long term missions and the Space Station with cell material. However, expertise for this venture is not at hand. A small and simple device for animal cell culture experiments aboard Spacelab (Dynamic Cell Culture System; DCCS) was developed. It provides 2 cell culture chambers, one is operated as a batch system, the other one as a perfusion system. The cell chambers have a volume of 200 microliters. Medium exchange is achieved with an automatic osmotic pump. The system is neither mechanically stirred nor equipped with sensors. Oxygen for cell growth is provided by a gas chamber that is adjacent to the cell chambers. The oxygen gradient produced by the growing cells serves to maintain the oxygen influx by diffusion. Hamster kidney cells growing on microcarriers were used to test the biological performance of the DCCS. On ground tests suggest that this system is feasible.     

CCSDS下行链路虚拟信道调度方法及其性能分析

描述了分包遥测的信源特点 ,并在此基础上提出了传送层虚拟信道划分和使用原则 ;利用轮询系统的方法建立了虚拟信道调度模型 ,从系统延时性能和缓存分配原则的角度 ,分析了不同信源组合下不同调度策略对系统可能造成的性能影响 ;提出了不同信源条件下适宜的调度策略和缓存分配策略。结果可为系统早期设计提供参考     

A simple closed aquatic ecosystem (CAES) for space

A closed aquatic ecosystem (CAES) was developed to study the effects of microgravity on the function of closed ecosystems aboard the Chinese retrieved satellite and on the spacecraft SHENZHOU-II. These systems housed a small freshwater snail (Bulinus australianus) and an autotrophic green algae (Chlorella pyrenoidosa). The results of the test on the satellite were that the concentration of algae changed little, but that the snails died during the experiments. We then sought to optimize the function of the control system, the cultural conditions and the data acquisition system and carried out an experiment on the spacecraft SHENZHOU-II. Using various sensors to monitor the CAES, real-time data regarding the operation of the CAES in microgravity was acquired. In addition, an on-board 1g centrifuge was included to identify gravity-related factors. It was found that microgravity is the major factor affecting the operation of the CAES in space. The change in biomass of the primary producer during each day in microgravity was larger than that of the control groups. The mean biomass concentration per day in the microgravity group decreased, but that of the control groups increased for several days and then leveled off. Space effects on the biomass of a primary producer may be a result of microgravity effects leading to increasing metabolic rates of the consumer combined with decreases in photosynthesis.     

Consistency of gas exchange of man and plants in a closed ecological system: lines of attack on the problem.

Gas exchange between man and plants in a closed ecological system based on atmosphere regeneration by plant photosynthesis is made consistent by attaining the equilibrium of human CO2 discharge and the productivity of the gas consuming bioregenerator. In this case the gas exchange might be, however, qualitatively disturbed from the equilibrium in terms of oxygen making it accumulate or decrease continuously in the air of the system. Gas exchange equilibrium in terms of O2 was attained in long-term experiments by equality of the human respiration coefficient and the plant assimilation coefficient. Varying the ratio of these parameters it is possible to control the oxygen concentration in the atmosphere to be reclaimed.     

Biomass recycle as a means to improve the energy efficiency of CELSS algal culture systems.

Algal cultures can be very rapid and efficient means to generate biomass and regenerate the atmosphere for closed environmental life support systems. However, as in the case of most higher plants, a significant fraction of the biomass produced by most algae cannot be directly converted to a useful food product by standard food technology procedures. This waste biomass will serve as an energy drain on the overall system unless it can be efficiently recycled without a significant loss of its energy content. We report experiments in which cultures of the algae Scenedesmus obliquus were grown in the light and at the expense of an added carbon source, which either replaced or supplemented the actinic light. As part of these experiments we tested hydrolyzed waste biomass from these same algae to determine whether the algae themselves could be made part of the biological recycling process. Results indicate that hydrolyzed algal (and plant) biomass can serve as carbon and energy sources for the growth of these algae, suggesting that the efficiency of the closed system could be significantly improved using this recycling process.     

三床型机载制氧系统控制设计与实验验证

为解决两床型机载制氧系统在实际应用过程中出现的输出压力波动大及低空氧浓度偏高等问题,需研制与开发三床型机载制氧系统。为此,依据系统控制逻辑,采用电磁阀驱动电控气动阀循环工作的控制模式,开展了三床型机载制氧系统的控制设计,提出了高低空分段调节循环周期的控制方法,并在不同输入压力、流量条件下,对三床型机载制氧系统进行了循环周期实验,探索了产品气氧浓度随循环周期时间的变化规律。研究结果表明:当采用高空循环周期为6 s,低空循环周期为9 s,高低空分段高度为3.5 km等控制参数时,系统控制设计可适用于三床型机载制氧系统,并满足三床型机载制氧系统控制设计的需求。      

Mass exchange in an experimental new-generation life support system model based on biological regeneration of environment.

An experimental model of a biological life support system was used to evaluate qualitative and quantitative parameters of the internal mass exchange. The photosynthesizing unit included the higher plant component (wheat and radish), and the heterotrophic unit consisted of a soil-like substrate, California worms, mushrooms and microbial microflora. The gas mass exchange involved evolution of oxygen by the photosynthesizing component and its uptake by the heterotroph component along with the formation and maintaining of the SLS structure, growth of mushrooms and California worms, human respiration, and some other processes. Human presence in the system in the form of "virtual human" that at regular intervals took part in the respirative gas exchange during the experiment. Experimental data demonstrated good oxygen/carbon dioxide balance, and the closure of the cycles of these gases was almost complete. The water cycle was nearly 100% closed. The main components in the water mass exchange were transpiration water and the watering solution with mineral elements. Human consumption of the edible plant biomass (grains and roots) was simulated by processing these products by a unique physicochemical method of oxidizing them to inorganic mineral compounds, which were then returned into the system and fully assimilated by the plants. The oxidation was achieved by "wet combustion" of organic biomass, using hydrogen peroxide following a special procedure, which does not require high temperature and pressure. Hydrogen peroxide is produced from the water inside the system. The closure of the cycle was estimated for individual elements and compounds. Stoichiometric proportions are given for the main components included in the experimental model of the system. Approaches to the mathematical modeling of the cycling processes are discussed, using the data of the experimental model. Nitrogen, as a representative of biogenic elements, shows an almost 100% closure of the cycle inside the system. The proposed experimental model of a biological system is discussed as a candidate for potential application in the investigations aimed at creating ecosystems with largely closed cycles of the internal mass exchange. The formation and maintenance of sustainable cycling of vitally important chemical elements and compounds in biological life support systems (BLSS) is an extremely pressing problem. To attain the stable functioning of biological life support systems (BLSS) and to maintain a high degree of closure of material cycles in than, it is essential to understand the character of mass exchange processes and stoichiometnc proportions of the initial and synthesized components of the system.