Tightly closed ecological systems reveal atmospheric subtleties – experience from Biosphere 2

Processes which produce slow changes in air composition in a closed ecological system (CES) may not be noticed if the leak rate of the CES is significant. Dilution of the system’s air with outside air can mask these processes. A tightly closed CES provides the opportunity for slow changes to accumulate over time and be observed and measured. Biosphere 2 (volume 200,000 m³) had a low leak rate of less than 10 percent per year. Oxygen declined slowly at varying rates reflecting seasonal influences, which averaged to about 140 ppm per day during the first 16 months of the two-year closure. Computer simulations of the observed rate of oxygen loss combined with other hypothetical leak rates suggest that the decline would have been hidden by a leak rate as low as one percent per day. Sealing Biosphere 2 involved rigorous design specifications and inclusion of two expansion chambers (called “lungs”) to accommodate expansion/contraction of the atmosphere, which enabled limiting the pressure difference between inside and outside atmospheres to the range of ±8 Pa (0.08 mBar). Measurement of leak rate was by two methods: the first, measuring the rate of deflation of the lungs while holding a constant elevated pressure differential enabled calculation of an estimated leak rate within the usual operating pressure differential range; the second was to measure the progressive dilution of trace gases spiked into the atmosphere. Both methods confirmed leakage to be less than 10 percent per year. Operational data from the 40 m³ Laboratory Biosphere is used to illustrate how normal variations of temperature, humidity and barometric pressure would combine to force leakage and rapidly dilute the internal atmosphere if it were not equipped with a lung. It is demonstrated that very high degrees of closure for a CES enable experimental observation of small imbalances in atmospheric cycles or slow accumulation of trace gases that could otherwise be masked by dilution with atmosphere external to the CES.     

Carbon dioxide exchange of lettuce plants under hypobaric conditions.

Growth of plants in a Controlled Ecological Life Support System (CELSS) may involve the use of hypobaric pressures enabling lower mass requirements for atmospheres and possible enhancement of crop productivity. A controlled environment plant growth chamber with hypobaric capability designed and built at Ames Research Center was used to determine if reduced pressures influence the rates of photosynthesis (Ps) and dark respiration (DR) of hydroponically grown lettuce plants. The chamber, referred to as a plant volatiles chamber (PVC), has a growing area of about 0.2 m2, a total gas volume of about 0.7 m3, and a leak rate at 50 kPa of <0.1%/day. When the pressure in the chamber was reduced from ambient to 51 kPa, the rate of net Ps increased by 25% and the rate of DR decreased by 40%. The rate of Ps increased linearly with decreasing pressure. There was a greater effect of reduced pressure at 41 Pa CO2 than at 81 Pa CO2. This is consistent with reports showing greater inhibition of photorespiration (Pr) in reduced O2 at low CO2 concentrations. When the partial pressure of O2 was held constant but the total pressure was varied between 51 and 101 kPa, the rate of CO2 uptake was nearly constant, suggesting that low pressure enhancement of Ps may be mainly attributable to lowered partial pressure of O2 and the accompanying reduction in Pr. The effects of lowered partial pressure of O2 on Ps and DR could result in substantial increases in the rates of biomass production, enabling rapid throughput of crops or allowing flexibility in the use of mass and energy resources for a CELSS.     

Carbon dioxide exchange of lettuce plants under hypobaric conditions.

Growth of plants in a Controlled Ecological Life Support System (CELSS) may involve the use of hypobaric pressures enabling lower mass requirements for atmospheres and possible enhancement of crop productivity. A controlled environment plant growth chamber with hypobaric capability designed and built at Ames Research Center was used to determine if reduced pressures influence the rates of photosynthesis (Ps) and dark respiration (DR) of hydroponically grown lettuce plants. The chamber, referred to as a plant volatiles chamber (PVC), has a growing area of about 0.2 m2, a total gas volume of about 0.7 m3, and a leak rate at 50 kPa of <0.1%/day. When the pressure in the chamber was reduced from ambient to 51 kPa, the rate of net Ps increased by 25% and the rate of DR decreased by 40%. The rate of Ps increased linearly with decreasing pressure. There was a greater effect of reduced pressure at 41 Pa CO2 than at 81 Pa CO2. This is consistent with reports showing greater inhibition of photorespiration (Pr) in reduced O2 at low CO2 concentrations. When the partial pressure of O2 was held constant but the total pressure was varied between 51 and 101 kPa, the rate of CO2 uptake was nearly constant, suggesting that low pressure enhancement of Ps may be mainly attributable to lowered partial pressure of O2 and the accompanying reduction in Pr. The effects of lowered partial pressure of O2 on Ps and DR could result in substantial increases in the rates of biomass production, enabling rapid throughput of crops or allowing flexibility in the use of mass and energy resources for a CELSS.     

Achieving and documenting closure in plant growth facilities.

As NASA proceeds with its effort to develop a Controlled Ecological Life Support System (CELSS) that will provide life support to crews during long duration space missions, it must address the question of facility and system closure. Here we discuss the concept of closure as it pertains to CELSS and describe engineering specifications, construction problems and monitoring procedures used in the development and operation of a closed plant growth facility for the CELSS program. A plant growth facility is one of several modules required for a CELSS. A prototype of this module at Kennedy Space Center is the large (7m tall x 3.5m diameter) Biomass Production Chamber (BPC), the central facility of the CELSS Breadboard Project. The BPC is atmospherically sealed to a leak rate of approximately 5% of its total volume per 24 hours. This paper will discuss the requirements for atmospheric closure in this facility, present CO2 and trace gas data from initial tests of the BPC with and without plants, and describe how the chamber was sealed atmospherically. Implications that research conducted in this type of facility will have for the CELSS program are discussed.     

正压漏孔校准装置定容室容积测量方法研究

提出了一种正压漏可孔校准装置的定容室容积测量方法,通过在定容室上外接一个容器,并在其内部放置一个体积可以精确计量的金属棒,利用两次膨胀,计算出定容室的容积。该方法的优点是,不需要测量外接容器的容积,也不需要对压力测量值进行绝对校准,测量不确定度小,尤其适合小容积的精确测量。采用这种方法对一台恒压式正压漏孔校准装置的定容室容积进行了测量,分析了测量不确定度,实验结果表明,定容室的容积为9.85 mL,标准不确定度为0.81%,满足了装置的测量要求。     

Atmospheric leakage and method for measurement of gas exchange rates of a crop stand at reduced pressure.

The variable pressure growth chamber (VPGC) was used in a 34-day functional test to grow a wheat crop using reduced pressure (70 kPa) episodes totalling 131 hours. Primary goals of the test were to verify facility and subsystem performance at 70 kPa and to determine responses of a wheat stand to reduced pressure and modified partial pressures of carbon dioxide and oxygen. Operation and maintenance of the chamber at 70 kpa involved continuous evacuation of the chamber atmosphere, leading to CO2 influx and efflux. A model for calculating CO2-exchange rates (net photosynthesis and dark respiration) was developed and tested and involved measurements of chamber leakage to determine appropriate corrections. Measurement of chamber leakage was based on the rate of pressure change over a small pressure increment (70.3 to 72.3 kPa) with the pump disabled. Leakage values were used to correct decreases and increases in chamber CO2 concentration resulting from net photosynthesis (Ps) and dark respiration (DR), respectively. Composite leakage corrections (influx and efflux) at day 7 of the test were 9% and 19% of the changes measured for Ps and DR, respectively. On day 33, composite corrections were only 3% for Ps and 4% for DR. During the test, the chamber became progressively tighter; the leak rate at 70.3 kPa decreasing from 2.36 chamber volumes/day pretest, to 1.71 volumes/day at the beginning of the test, and 1.16 volumes/day at the end of the test. Verification of the short-term leakage tests (rate of pressure rise) were made by testing CO2 leakage with the vacuum pump enabled and disabled. Results demonstrate the suitability of the VPGC or conducting gas exhange measurements of a crop stand at reduced pressure.     

An overview of Japanese CELSS research activities.

Many research activities regarding Controlled Ecological Life Support System (CELSS) have been conducted and continued all over the world since the 1960's and the concept of CELSS is now changing from Science Fiction to Scientific Reality. Development of CELSS technology is inevitable for future long duration stays of human beings in space, for lunar base construction and for manned mars flight programs. CELSS functions can be divided into two categories, Environment Control and Material Recycling. Temperature, humidity, total atmospheric pressure and partial pressure of oxygen and carbon dioxide, necessary for all living things, are to be controlled by the environment control function. This function can be performed by technologies already developed and used as the Environment Control Life Support System (ECLSS) of Space Shuttle and Space Station. As for material recycling, matured technologies have not yet been established for fully satisfying the specific metabolic requirements of each living thing including human beings. Therefore, research activities for establishing CELSS technology should be focused on material recycling technologies using biological systems such as plants and animals and physico-chemical systems, for example, a gas recycling system, a water purifying and recycling system and a waste management system. Based on these considerations, Japanese research activities have been conducted and will be continued under the tentative guideline of CELSS research activities as shown in documents /1/, /2/. The status of the over all activities are discussed in this paper.     

A simplified closed artificial ecosystem--recycling of organic matter into wheat plants.

A simplified closed system consisting of a plant growth chamber coupled to a decomposition chamber was used to study carbon exchange dynamics. The CO2 produced via the decomposition of wheat straw was used for photosynthetic carbon uptake by wheat plants. The atmosphere of the two chambers was connected through a circuit of known flow rate. Thus, monitoring the CO2 concentrations in both compartments allowed measurement of the carbon exchange between the chambers, and estimation of the rate of respiration processes in the decomposition chamber and photosynthetic rate in the producer chamber. The objective for CELSS research was to simulate a system where a compartment producing food via photosynthesis, would be supplied by CO2 produced from respiration processes. The decomposition of biomass by the decomposer simulated both the metabolism of a crew and the result of a recycling system for inedible biomass. Concerning terrestrial ecosystems, the objective was to study organic matter decomposition in soil and other processes related to permanent grasslands.     

Ethylene production by plants in a closed environment.

Ethylene production by 20-m2 stands of wheat, soybean, lettuce and potato was monitored throughout growth and development in NASA's Controlled Ecological Life Support System (CELSS) Biomass Production Chamber. Chamber ethylene concentrations rose during periods of rapid growth for all four species, reaching 120 parts per billion (ppb) for wheat, 60 ppb for soybean, and 40 to 50 ppb for lettuce and potato. Following this, ethylene concentrations declined during seed fill and maturation (wheat and soybean), or remained relatively constant (potato). Lettuce plants were harvested during rapid growth and peak ethylene production. The highest ethylene production rates (unadjusted for chamber leakage) ranged from 0.04 to 0.06 ml m-2 day-1 during rapid growth of lettuce and wheat stands, or approximately 0.8 to 1.1 nl g-1 fresh weight h-1. Results suggest that ethylene production by plants is a normal event coupled to periods of rapid metabolic activity, and that ethylene removal or control measures should be considered for growing crops in a tightly closed CELSS.     

Effects of air current speed on gas exchange in plant leaves and plant canopies.

To obtain basic data on adequate air circulation to enhance plant growth in a closed plant culture system in a controlled ecological life support system (CELSS), an investigation was made of the effects of the air current speed ranging from 0.01 to 1.0 m s-1 on photosynthesis and transpiration in sweetpotato leaves and photosynthesis in tomato seedlings canopies. The gas exchange rates in leaves and canopies were determined by using a chamber method with an infrared gas analyzer. The net photosynthetic rate and the transpiration rate increased significantly as the air current speeds increased from 0.01 to 0.2 m s-1. The transpiration rate increased gradually at air current speeds ranging from 0.2 to 1.0 m s-1 while the net photosynthetic rate was almost constant at air current speeds ranging from 0.5 to 1.0 m s-1. The increase in the net photosynthetic and transpiration rates were strongly dependent on decreased boundary-layer resistances against gas diffusion. The net photosynthetic rate of the plant canopy was doubled by an increased air current speed from 0.1 to 1.0 m s-1 above the plant canopy. The results demonstrate the importance of air movement around plants for enhancing the gas exchange in the leaf, especially in plant canopies in the CELSS.     

Survey of CELSS concepts and preliminary research in Japan

Many agricultural and other experiments relating to the development of a Controlled Ecological Life Support System (CELSS) were proposed by scientists throughout Japan in the fall of 1982. To develop concrete experimental concepts from these proposals, the engineering feasibility of each proposal was investigated by a CELLS experiment concept study group under the support of the National Aerospace Laboratory. The conclusions of the group were described in two documents, /1/, /2/. Originally, the study group did not clearly define necessary missions leading to the goal of an operational CELSS for spaceflight. Therefore, the CELSS experiment concept study group met again to clarify the goals of CELSS and to determine three phases to achieve the goals. The resulting phases, or missions, and preliminary proposals and studies needed to develop a CELLS are described herein.     

Significance of rhizosphere microorganisms in reclaiming water in a CELSS.

Plant-microbe interactions, such as those of the rhizosphere, may be ideally suited for recycling water in a Controlled Ecological Life Support System (CELSS). The primary contaminant of waste hygiene water will be surfactants or soaps. We identified changes in the microbial ecology in the rhizosphere of hydroponical1y grown lettuce during exposure to surfactant. Six week old lettuce plants were transferred into a chamber with a recirculating hydroponic system. Microbial density and population composition were determined for the nutrient solution prior to introduction of plants and then again with plants prior to surfactant addition. The surfactant Igepon was added to the recirculating nutrient solution to a final concentration of 1.0 g L-1. Bacteria density and species diversity of the solution were monitored over a 72-h period following introduction of Igepon. Nine distinct bacterial types were identified in the rhisosphere; three species accounted for 87% of the normal rhizosphere population. Microbial cell number increased in the presence of Igepon, however species diversity declined. At the point when Igepon was degraded from solution, diversity was reduced to only two species. Igepon was found to be degraded directly by only one species found in the rhizosphere. Since surfactants are degraded from the waste hygiene water within 24 h, the potential for using rhizosphere bacteria as a waste processor in a CELSS is promising.     

Systematic approach to life support system analyses and integration.

This paper is devoted to the consideration of possible viewpoint on CELSS development and design. If the aim to create practically applicable CELSS is accepted then the task to optimize the process of CELSS research and development in terms of minimum cost, hours, maximum applicability, scientific contribution, etc. becomes actual. Requirements of applicability and scientific significance are synergetic since understanding of general properties of CELSS gives an ability to create CELSS for different applications. To accomplish the task three main groups of parameters have to be optimized: i) configuration and operating parameters of developing CELSS itself; ii) organizational management of research and development of CELSS; iii) features of an area where CELSS is planned to be used (space missions, terrestrial applications, or biosphere investigation) and where requirements to CELSS characteristic come from. Given paper is a brief review presented some attempts to arrange mentioned above into some set of formalized and interacting criteria, and some progression of research stages derived from these criteria.     

中国空间站燃烧科学实验系统燃烧室设计与分析

中国空间站燃烧科学实验系统能够在轨进行多种燃料的微重力燃烧实验，其关键组件燃烧室是可实现密封的压力容器，为实验插件提供机械、氧化剂、废气排放、供电、控制、冷却等接口，支持实验插件完成相关功能.本文依据承压范围、漏率、透射光波段等设计技术指标进行燃烧室结构设计与力学分析.燃烧室采用分段式结构，由合叶门、锁紧圈、连接环、筒体等组件依次连接组成，连接结构处使用密封圈.通过燃烧室的承压分析、模态分析以及随机响应分析，校核了燃烧室结构的强度、刚度及随机振动响应特性，验证了燃烧室设计的安全性与可靠性，能够满足发射及在轨工作要求.      

并联接入式气体泄漏量的测量方法

并联接入式流量测量方法与串联式测量方法相比,接入简单,装卸不需要破坏管道.引入基准流量,根据基准流量发生前后压缩气体的压力变化率可以求解泄漏流量;采用基于非线性微分跟踪器的滤波方法对压力信号滤波,有效消除了噪声的影响.实验结果表明:并连接入式的测量方法测量精度可达到满量程3%,重复精度可达满量程3%,适用于气动节能工业.     

The Breadboard Project: a functioning CELSS plant growth system.

The primary objective of the Breadboard project for the next 3-4 years is to develop, integrate and operate a Controlled Ecological Life Support System (CELSS) at a one person scale. The focus of this project over the past two years has been the development of the plant growth facility, the first module of the CELSS. The other major modules, food preparation, biomass processing, and resource recovery, have been researched at the laboratory scale during the past two years and facilities are currently under construction to scale-up these modules to an operational state. This paper will outline the design requirements for the Biomass Production Chamber (BPC), the plant growth facility for the project, and the control and monitoring subsystems which operate the chamber and will present results from both engineering and biological tests of the facility. Three production evaluations of wheat, conducted in the BPC during the past year, will be described and the data generated from these tests discussed. Future plans for the BPC will be presented along with future goals for the project as the other modules become active.     

Fundamental study on gas monitoring in CELSS.

A mass spectrometer and computer system was developed for conducting a fundamental study on gas monitoring in CELSS. Respiration and metabolism of the hamster and photosynthesis of the Spirulina were measured in a combination system consisting of a hamster chamber and a Spirulina cultivator. They are connected through a membrane gas exchanger. Some technical problems were examined. In the mass spectrometric gas monitoring, a simultaneous multi-sample measurement was developed by employing a rotating exchange valve. Long term precise measurement was obtained by employing an automatic calibration system. The membrane gas sampling probe proved to be useful for long term measurement. The cultivation rate of the Spirulina was effectively changed by controlling CO2 and light supply. The experimental results are helpful for improving the hamster-spirulina system.     

Utilization of sweet potatoes in controlled ecological life support systems (CELSS).

A number of studies have selected the sweet potato as a potentially important crop for CELSS. Most hydroponic studies of sweet potatoes have been short term (<80 days). Full term (90 to 150 days) studies of sweet potatoes in hydroponic systems were needed to understand the physiology of storage root enlargement and to evaluate sweet potato production potential for CELSS. Early and late maturing sweet potato varieties were crown in hydroponic systems of different types--static with periodic replacement, flowing with and without recirculation, aggregate, and non-aggregate. In a flowing system with recirculation designed at Tuskegee University using the nutrient film technique (NFT), storage root yields as high as 1790 g were produced with an edible growth rate of up to 66 g m-2 d-1 and a harvest index as high as 89% under greenhouse conditions. Preliminary experiments indicated high yields can be obtained in controlled environmental chambers. Significant cultivar differences were found in all systems studied. Nutritive composition of storage roots and foliage were similar to field-grown plants. The results indicate great potential for sweet potato in CELSS.