中心进气转静盘腔的冷气流阻特性实验

李夫庆; 罗翔; 徐国强

中心进气转静盘腔的冷气流阻特性实验

北京航空航天大学能源与动力工程学院航空发动机气动热力国家级重点实验室,北京 100191

基金项目: 国家自然科学基金(50806004)

计量
- 文章访问数: 1606
- HTML浏览量: 0
- PDF量: 17
- 被引次数: 0
出版历程
- 收稿日期: 2010-05-24
- 修回日期: 2010-09-19
- 刊出日期: 2011-06-28

Experimental study of flow friction characteristics for a rotor-stator system with centre inflow of cooling air

National Key Laboratory of Science and Technology on Aero-Engines Aero-thermodynamics, School of Jet Propulsion,Beijing University or Aeronautics and Astronautics, Beijing 100191,China

摘要

摘要: 采用实验的方法,对两种封严结构的中心进气转静系盘腔冷气流动阻力特性进行了研究.实验结果显示:阻力系数随间隙比和流量系数的增大而减小,随旋转雷诺数的增大而增大.在静止时,间隙比对阻力系数的影响要大于流量系数对它的影响;在旋转时,间隙比对阻力系数的影响要小于流量系数和旋转雷诺数对它的影响.
- 转静系 /
- 旋转盘腔 /
- 总压损失 /
- 阻力系数 /
- 封严结构
Abstract: The friction characteristics of a rotor-stator system with centre inflow of cooling air for two sealing geometry were experimentally studied.The experimental results show that:the friction coefficient will decline with the increasing ratio of sealing clearance and mass flow coefficient,and increase with the rotating Reynolds number.For the stationary case,the ratio of sealing clearance affects the friction coefficient much obviously than the mass flow coefficient;for the rotating case,the ratio of sealing clearance affects the friction coefficient less obviously than the mass flow coefficient and the rotating Reynolds number.
- rotator-stator system /
- rotating cavity /
- total pressure loss /

HTML

参考文献(12)

[1]	曹玉璋,陶智,徐国强,等.航空发动机传热学[M].北京:北京航空航天大学出版,2005:226-264.
[2]	Phadke U P,Owen J M.Aerodynamic aspects of the sealing of gas-turbine rotor-stator systems Part 1:the behavior of simple shrouded rotating-disk systems in a quiescent environment[J].Heat and Fluid Flow,1988,9(2):98-10.
[3]	Karabay H,Wilson M,Owen J M.Approximate solutions for flow and heat transfer in pre-swirl rotating-disc system .ASME Paper 2001-GT-0200,2001.
[4]	Yan Y Y,Gord M F,Lock G D,et al.Fluid dynamics of a pre-swirl rotor-stator system .ASME Paper 2002-GT-30415,2002.
[5]	Pilbrow R,Karabay H,Wilson M,et al.Heat transfer in a “cover-plate” pre-swirl rotating-disc system[J].Journal of Turbomachinery,1999,121(2):249-256.
[6]	Lock G D,Wilson M,Owen J M.Influence of fluid-dynamics on heat transfer in a pre-swirl rotating-disc system .ASME Paper 2004-GT-53158,2004.
[7]	Newton P J,Yan Y Y,Owen J M.Transient heat transfer measurements using thermochromic liquid crystal Part 1:an improved technique[J].Heat and Fluid Flow,2003,24(1):14-22.
[8]	Lock G D,Yan Y Y,Newton P J.Heat transfer measurements using liquid crystals ina pre swirl rotating-disk system[J].Journal of Engineering for Gas Turbines and Power,2005,127(2):375-381.
[9]	罗翔,徐国强,蔡毅,等.中心进气转静盘腔的流量分配特性试验[J].航空动力学报,2007,22(6):73-876. LUO Xiang,XU Guoqiang,CAI Yi,et al.Experimental study of flow distribution characteristics for a rator-stator system[J].Journal of Aerospace Power,2007,22(6):873-876.(in Chinese)
[10]	丁水汀,陶智,徐国强,等.旋转盘腔冷却问题的工程评价[J].航空动力学报,1999,14(1):83-84. DING Shuiting,TAO Zhi,XU Guoqiang,et al.An engineering evaluation system of turbine disk cooling congiguration[J].Journal of Aerospace Power,1999,14(1):83-84.(in Chinese)
[11]	Owen J M.An approximate solution for flow between a rotating and a stationary disk[J].Journal of Turbomachinery,1989,111(3):323-332.
[12]	Owen J M,Rogers R H.Flow and heat transfer in rotating disk systems [M].UK:Research Studies Press,1989:301-325.