同转/对转双转子系统的动力学特性

蒋云帆; 廖明夫; 刘永泉; 王德友; 金路; 鲁鹏

同转/对转双转子系统的动力学特性

1.
西北工业大学动力与能源学院, 西安 710007
2.
中国航空工业集团公司沈阳发动机设计研究所, 沈阳 110015

计量
- 文章访问数: 1311
- HTML浏览量: 1
- PDF量: 1036
- 被引次数: 0
出版历程
- 收稿日期: 2012-11-15
- 刊出日期: 2013-12-28

Dynamic characteristics of co-rotating/counter-rotating dual-rotor system

1.
School of Power and Energy, Northwestern Polytechnical University, Xi'an 710007
2.
Shenyang Engine Design and Research Institute, Aviation Industry Corporation of China, Shenyang 110015, China

摘要

摘要: 建立了双转子动力学模型，引入中介轴承刚度和高、低压转子陀螺力矩的影响，利用数值分析和实验验证，揭示了同转/对转双转子系统临界转速特性和不平衡响应存在的差异，以及转速比对同转/对转双转子临界转速特性和不平衡响应的影响.结果表明：陀螺力矩是影响带有中介支承的双转子系统转子刚度的主要原因，其刚度变化与内、外转子的转速比大小和相对旋转方向有关，进而导致同转/对转双转子系统临界转速特性和不平衡响应发生改变；相比同结构的同转双转子，在相同的不平衡量作用下，对转双转子的不平衡响应更为显著.对转双转子进行动平衡时，应更加严格的控制内、外转子的不平衡量.
- 双转子 /
- 同转 /
- 对转 /
- 陀螺力矩 /
- 动力学特性
Abstract: A dynamic model of dual-rotor was set up.The influence of inter-shaft bearing stiffness and the gyroscopic moments of high and low pressure rotors were considered in this model.The difference of co-rotating or counter-rotating dual-rotor's critical speed characteristics and unbalance response and the influence of speed ratio on co-rotating or counter-rotating dual-rotor's critical speed characteristics and unbalance response were revealed by numerical analysis and experiments.The results show that,gyroscopic moment is a main influential factor to the rotor stiffness of dual-rotor system with inter-shaft bearing,and the changes of stiffness are related to the speed ratio and the relative rotating direction of inner and outer rotors,further causing the change of co-rotating or counter-rotating dual-rotor's critical speed characteristics and unbalance response.Compared with the co-rotating dual-rotor of the same structure with the counter-rotating dual-rotor,the counter-rotating dual-rotor's unbalance response is more obvious than the co-rotating dual-rotor's under the same unbalance mass,and for this reason the unbalance mass of counter-rotating dual-rotor's inner and outer rotors should be controlled more strictly during the dynamic balance.
- dual-rotor /
- co-rotating /
- counter-rotating /
- gyroscopic moment /
- dynamic characteristic

HTML

参考文献(15)

[1]	胡绚, 罗贵火, 高德平.反向旋转双转子稳态响应计算分析与试验[J].航空动力学报, 2007, 22(7):1044-1049. HU Xuan, LUO Guihuo, GAO Deping.Numerical analysis and experiment of counter-rotating dual-rotor's steady state response[J].Journal of Aerospace Power, 2007, 22(7):1044 -1049.(in Chinese)
[2]	廖明夫, 于潇, 王四季, 等.双转子系统的振动[J].机械科学与技术, 2013, 32(4):475-480. LIAO Mingfu, YU Xiao, WANG Siji, et al.The vibration features of a twin spool rotor system[J].Mechanical Science and Technology for Aerospace Engineering, 2013, 32(4):475-480.(in Chinese)
[3]	廖明夫, 刘永泉, 王四季, 等.中介轴承对双转子振动的影响[J].机械科学与技术, 2013, 32(5):641-646. LIAO Mingfu, LIU Yongquan, WANG Siji, et al.The vibration features of a twin spool rotor system with an inter-bearing[J].Mechanical Science and Technology for Aerospace Engineering, 2013, 32(5):641-646.(in Chinese)
[4]	JIN Lu, LIAO Mingfu, WANG Siji.A whole transfer matrix method for the counter-rotating dual-rotor system[D].Xi'an:The 4th International Symposium on Jet Propulsion and Power Engineering Meeting, 2012.
[5]	柴山, 刚宪约, 姚福生, 等.计算多转子系统临界转速的整体传递矩阵法[J].上海理工大学学报, 2002, 24(1):8-12. CHAI Shan, GANG Xianyue, YAO Fusheng, et al.A whole transfer matrix method for calculating the critical speed of multi-rotor system[J].Journal of University of Shanghai for Science and Technology, 2002, 24(1):8-12.(in Chinese)
[6]	胡绚, 罗贵火, 高德平.反向旋转双转子系统动力特性分析[J].现代机械, 2007(4):45-49. HU Xuan, LUO Guihuo, GAO Deping.Dynamic performance analysis of counter-rotating dual-rotor system[J].Modern Machinery, 2007(4):45-49.(in Chinese)
[7]	罗贵火.反向旋转双转子系统振动特性分析与试验研究[D].南京:南京航空航天大学, 1999. LUO Guihuo.Analysis of vibration characteristic and research of experiment of dual-rotor system of opposite-rotating[D].Nanjing:Nanjing University of Aeronautics and Astronautics, 1999.(in Chinese)
[8]	冯国权, 岳承熙, 张连祥.对转式双转子发动机动特性分析[J].航空发动机, 1993(5):43-48.
[9]	冯国权, 张连祥, 伊峰.反向旋转双转子发动机稳态不平衡响应分析[J].哈尔滨工业大学学报, 1998, 30(增刊):249-252. FENG Guoquan, ZHANG Lianxiang, YI Feng.Stationary unbalance response analysis of a two-spool engine with counter-rotating rotors[J].Journal of Harbin Institute of Technology, 1998, 30(suppl.):249-252.(in Chinese)
[10]	胡绚.反向旋转双转子系统动力学特性研究[D].南京:南京航空航天大学, 2007. HU Xuan.Research on the dynamical characteristics of counter-rotating dual-rotor system[D].Nanjing:Nanjing University of Aeronautics and Astronautics, 2007.(in Chinese)
[11]	Ferraris G, Maisonneuve V, Lalanne M.Prediction of the dynamic behavior of non-symmetric coaxial co-or counter-rotating rotors[J].Journal of Sound and Vibration, 1996, 195(4):649-666.
[12]	JIANG Yunfan, LIAO Mingfu, WANG Siji.The design of counter-rotating dual-rotor experimental apparatus.Xi'an:The 4th International Symposium on Jet Propulsion and Power Engineering Meeting, 2012.
[13]	陈时锦, 张春玉.轴承刚度矩阵的解析推导与计算机求解[J].轴承, 2006(2):1-4. CHEN Shijin, ZHANG Chunyu.Analytic derivation and computer solution of rigidity matrix of bearings[J].Bearing, 2006(2):1-4.(in Chinese)
[14]	苟文选, 金保森, 卫丰, 等.材料力学[M].北京:科学出版社, 2005.
[15]	顾家柳, 丁奎元, 刘启洲, 等.转子动力学[M].北京:国防工业出版社, 1984.